3rd class stationary steam engineer license prep CORRECT 100%
1 view 0 purchase
Course
DC Boiler
Institution
DC Boiler
if the steam pressure gauge indicates 200 PSIG, the absolute pressure is______ - ANSWER 214.7
a boiler is operating at 400 PSI, and the safety valve opens at 410 PSI and closes at 398 PSI. The blowdown is______psi - ANSWER 12
an oil cooler is commonly used with a(n) ________ when operating in...
3rd class stationary steam engineer license
prep CORRECT 100%
_________ are necessary for complete combustion - ANSWER time, temperature, mixture, and
atomization
if the steam pressure gauge indicates 200 PSIG, the absolute pressure is______ - ANSWER 214.7
a boiler is operating at 400 PSI, and the safety valve opens at 410 PSI and closes at 398 PSI. The
blowdown is______psi - ANSWER 12
an oil cooler is commonly used with a(n) ________ when operating in conjunction with a turbo-
generator - ANSWER steam turbine
a boiler is producing 40,000lb of steam/hr at a pressure of 100 PSI and a steam temperature of 500
degrees Fahrenheit. The steam produced is _______ steam - ANSWER superheated
the economizer on a boiler is used to _______ - ANSWER add heat to the feed water
blowers are normally used with________ boilers - ANSWER water tube
overheating of tubes on a boiler can be caused by________ - ANSWER scale on tubes
carbon dioxide in a condensate return system causes_________ - ANSWER channeling
a ________ pump is a positive displacement pump - ANSWER reciprocating
a boiler generating 6000 lb of steam/hr produces _______btu/hr - ANSWER 6,000,000
, a bottom blowdown is performed on a boiler to _____ - ANSWER discharge sludge and sediment
water columns are connected to the boiler with a minimum of _______" pipe - ANSWER 1
the minimum size of a water column blowdown valve is_______". - ANSWER 3/4
the maximum size bottom blowdown valve on a boiler is_________". - ANSWER 2 1/2
a ________ allows condensate to pass through, but stops Steam. - ANSWER a steam trap
when taking over a shift, the first thing to do is check the________ - ANSWER water level in each boiler
according to the asme code, a high-pressure boiler having more than 500 square feet of heating surface
shall have________ - ANSWER two or more safety valves
the probable cause of an increase in temperature of gases of combustion at the boiler Outlet is____ -
ANSWER dirty heating services
boilers in battery equipped with________ must have two main steam stop valves and a free-flowing
drain between them - ANSWER manhole openings
in order to be sure the gauge glass is indicating an accurate water level reading, the stationary engineer
should______ - ANSWER blowdown the gauge glass
a continuous blowdown line is located___ - ANSWER in the Steam and water drum well below the nowl
a temperature reading of 80 degrees Celsius is equal to_________°f - ANSWER 176
a chimney temperature of 250 degrees Fahrenheit above steam temperature indicates_______ -
ANSWER poor efficiency
, a manometer is red in________ - ANSWER inches of water
the boiling point of water will____ with an increase in pressure - ANSWER be raised
if a lather is not obtained when performing a soap hardness test, the water sample is_______ - ANSWER
hard
combustion efficiency can be increased when air is________ - ANSWER preheated
______ draft is produced by a fan located between the boiler and the chimney - ANSWER induced
the overspeed trip on a steam turbine should be tested ______ - ANSWER before putting the steam
turbine on-line
a high CO2 reading in the gases of combustion is a sign of____ - ANSWER High combustion efficiency
the purpose of chemically treating feedwater is to________ - ANSWER turn scale-forming salts to a non
adhering sludge
water in a d rating feed water heater is prevented from entering the steam line by a(n) _______. -
ANSWER Loop seal or internal overflow
a steam turbine operating at 3600 RPM will trip at_________ rpm - ANSWER 3960
he steam line going to The Blowers is connected to the main ________ - ANSWER steam drum
before using blowers on a boiler,________ - ANSWER drain set blower lines
an accumulation of snow on the Fireside of a boiler tubes________ - ANSWER decreases boiler efficiency
The benefits of buying summaries with Stuvia:
Guaranteed quality through customer reviews
Stuvia customers have reviewed more than 700,000 summaries. This how you know that you are buying the best documents.
Quick and easy check-out
You can quickly pay through credit card or Stuvia-credit for the summaries. There is no membership needed.
Focus on what matters
Your fellow students write the study notes themselves, which is why the documents are always reliable and up-to-date. This ensures you quickly get to the core!
Frequently asked questions
What do I get when I buy this document?
You get a PDF, available immediately after your purchase. The purchased document is accessible anytime, anywhere and indefinitely through your profile.
Satisfaction guarantee: how does it work?
Our satisfaction guarantee ensures that you always find a study document that suits you well. You fill out a form, and our customer service team takes care of the rest.
Who am I buying these notes from?
Stuvia is a marketplace, so you are not buying this document from us, but from seller shantelleG. Stuvia facilitates payment to the seller.
Will I be stuck with a subscription?
No, you only buy these notes for $12.99. You're not tied to anything after your purchase.
