100% satisfaction guarantee Immediately available after payment Both online and in PDF No strings attached
logo-home
IICL Container Inspector's Exam Questions And Answers 2024/2025 $10.49
Add to cart

Exam (elaborations)

IICL Container Inspector's Exam Questions And Answers 2024/2025

 0 purchase
  • Course
  • IICL Container Inspector\\\'s
  • Institution
  • IICL Container Inspector\\\'s

IICL Container Inspector's Exam Questions And Answers 2024/2025 Which of the following defects requires repair? A. A loose door gasket B. A bent J-bar that does not affect door operation C. A dent 13mm (1/2 in) deep on the door sill D. Four dents, each 11mm (7/16 in) deep, on contiguous outbo...

[Show more]

Preview 3 out of 28  pages

  • November 9, 2024
  • 28
  • 2024/2025
  • Exam (elaborations)
  • Questions & answers
  • IICL Container Inspector's
  • IICL Container Inspector's
avatar-seller
learndirect
IICL Container Inspector's Exam Questions And Answers
2024/2025
Which of the following defects requires repair?

A. A loose door gasket

B. A bent J-bar that does not affect door operation

C. A dent 13mm (1/2 in) deep on the door sill

D. Four dents, each 11mm (7/16 in) deep, on contiguous outboard corrugations of a roof
panel - -A. A loose door gasket

Of the following conditions in a dry-van container, which one would require cleaning?

A. Raised mud foot prints in excess of what might normally remain after a sweep out

B. Dry dust covering dried floor stains as might normally be found after a sweep out

C. Coffee beans remaining inside the container as might occur after a sweep out

D. Polyurethane beads as might be expected to lodge in grooves between floorboards after
a sweep out - -C. Coffee beans remaining inside the container as might occur after a
sweep out

An Equipment Interchange Receipt (EIR), based on an inspection with no damage found,
can be evidence of a container's compliance with: A. Australian Timber Component
Treatment Regulations B. Convention for Safe Containers (CSC) regulations through the
ACEP Program

C. Transport under custom's seal (TIR) regulations D. International Standards Organization
(ISO) CEDEX codes regulations - -B. Convention for Safe Containers (CSC)
regulations through the ACEP Program

The top of a replacement plastic ventilator should be centered what distance from the top
side rail? A. 50-55mm (2-2 3/16 in) B. 70-75mm (2 5/8 - 3 in)

C. 100mm (4in) D. 150mm (6 in) - -A. 50-55mm (2-2 3/16 in)

, IICL Container Inspector's Exam Questions And Answers
2024/2025
When must a reference line extend the full length of a bottom side rail? A. When there are
two or more areas of damage on the bottom side rail B. When there is a sharp bend in the
bottom side rail

C. When there is a bowing over the entire bottom side rail D. When there is additional
damage to the bottom side rail so that the reference line cannot be positioned over the
ends of the damage - -C. When there is a bowing over the entire bottom side rail

Which of the following is NOT a transverse structural member of the container?

A. Front sill B. Tunnel rail

C. Rear header

D. Crossmember - -B. Tunnel rail

A steel corner fitting is being replaced. To ensure better weld penetration, IICL
recommends that the edges of parts adjacent to the corner fitting be ground to a minimum
bevel of? A. 30 degrees B. 45 degrees

C. 55 degrees D. 60 degrees - -B. 45 degrees

Which of the following components is sometimes placed longitudinally in the container to
support plywood flooring? A. Transverse bow B. Gusset

C. Hat section center spacer

D. Threshold plate - -C. Hat section center spacer

Assuming owner and environmental regulations permit, which of the following procedures
is NOT recommended for repairing tarpaulins or open top containers? A. Cleaning the area
to be covered with acetone or mineral spirit B. Using a heat gun to fuse a patch to the
tarpaulin C. Sewing on a patch of the same material as the tarpaulin D. Repairing a 6 mm
(1/4 in ) pin hole with an epoxy compound - -C. Sewing on a patch of the same
material as the tarpaulin

, IICL Container Inspector's Exam Questions And Answers
2024/2025
Which of the following is an example of a plank floor condition requiring repair AND which
should be considered as damage?

A. A crack or split with no evidence of impact, which leaks light

B. A crack or split with a sign of impact which does not leak light

C. A crack or split, adjacent to a dented bottom rail, which leaks light

D. A crack or split, with no evidence of impact, with a loose piece - -C. A crack or
split, adjacent to a dented bottom rail, which leaks light

Welds to corner fittings should be made with?

A. CO2 semi-automatic welding

B. Low hydrogen welding rods

C. Fully automatic welding

D. Arc welding - -B. Low hydrogen welding rods

All of the following procedures are required EXCEPT

A. Weld smoke, spatter, etc. must be removed to permit adhesion of paint

B. The damaged component(s) must be restored as close as possible to original size and
profile

C. Welds must be examined using radiographic or magnetic particle non-destructive
testing equipment

D. Replacement steel components must be painted with coating compatible with that
originally applied to the container - -C. Welds must be examined using radiographic
or magnetic particle non-destructive testing equipment

Where should the reference line be placed in order to determine repairworthiness of a
crossmember flange that is bent upwards?

The benefits of buying summaries with Stuvia:

Guaranteed quality through customer reviews

Guaranteed quality through customer reviews

Stuvia customers have reviewed more than 700,000 summaries. This how you know that you are buying the best documents.

Quick and easy check-out

Quick and easy check-out

You can quickly pay through credit card or Stuvia-credit for the summaries. There is no membership needed.

Focus on what matters

Focus on what matters

Your fellow students write the study notes themselves, which is why the documents are always reliable and up-to-date. This ensures you quickly get to the core!

Frequently asked questions

What do I get when I buy this document?

You get a PDF, available immediately after your purchase. The purchased document is accessible anytime, anywhere and indefinitely through your profile.

Satisfaction guarantee: how does it work?

Our satisfaction guarantee ensures that you always find a study document that suits you well. You fill out a form, and our customer service team takes care of the rest.

Who am I buying these notes from?

Stuvia is a marketplace, so you are not buying this document from us, but from seller learndirect. Stuvia facilitates payment to the seller.

Will I be stuck with a subscription?

No, you only buy these notes for $10.49. You're not tied to anything after your purchase.

Can Stuvia be trusted?

4.6 stars on Google & Trustpilot (+1000 reviews)

64670 documents were sold in the last 30 days

Founded in 2010, the go-to place to buy study notes for 15 years now

Start selling
$10.49
  • (0)
Add to cart
Added